How deep should a concrete spur be repaired?
The amount required of either product depends on the size of the hole that the spur is going into When concreting repair spurs into the ground the posts should be buried a minimum depth of 2ft into the ground
Can you concrete in fence post spikes?
Concrete-in fence post holders are designed for use where soil conditions are unsuitable for drive-in spikes The “shoe” should be set into a 450mm (18 inch) cube of concrete so that the base plate sits flush with the surface of the concrete Don’t forget to check it is level before allowing the concrete to go off!
What is a concrete repair spur?
The Supreme Concrete Repair Spur is used to support fence panels by bracing or repairing an existing fence It is designed to repair timber fence posts that have rotted at the base
How long do concrete Spurs last?
Concrete spurs last for around 25 years compared to 10 to 15 years for treated spruce If untreated the spruce may need replacing in under 5 years Once they begin to rot they also start to pose a safety risk if not replaced soon
Can you cement a Metpost?
Metpost System 2 Concrete In Anchor for 75mm and 100mm Posts As the name suggests the sockets are fixed into postion using concrete rather driven into the ground Metpost Wedge Grip Concrete In Anchors come in two sizes enabling 75mm and 100mm posts to be easily fixed
Can I concrete in a Metpost?
The Metpost system contains everything you need to put up a fence or pergola Fixings can hold fence posts either by a wedge grip or bolt-tightening ‘system 2’ Post holders can then be driven into the ground, concreted-in or bolted down
How long does it take concrete to set in a post hole?
Typically, you can apply some weight to the posts after 4 hours, but it’s a good idea to wait at least 24 hours before resuming fence construction Standard concrete mixes may take up to two hours to set and should cure for 24 to 48 hours before any forces are applied to the posts
How do Fence Post Spikes work?
The fence spike is a large red spike you hammer it into position with a woodblock, insert the fence post and screw together This method is good for novices but does not stand up to the test of time Fence spikes really are a very temporary solution and should never be used for a long-standing fence
What is the difference between Postcrete and concrete?
Depending on its application, traditional concrete can take between 24-48 hours and 7 days to set properly and will reach its optimum strength after 25-28 days Postcrete, on the other hand, is the name given to a post mix concrete, which is a ready to use blend of concrete ingredients that requires no mixing
Why are my fence posts wobbling?
Posts that have been in the ground for less than five years usually wobble because of improper installation; ordinarily, tightening them is fairly easy In older fences, decay is more likely the culprit Although strengthening a decayed post sometimes works, the best solution is to replace it
Why is my new fence wobble?
Fence wobble occurs when a fence post has lost its secure position, creates space, and becomes loose in the post hole If left unattended, the jarring of the post back and forth will cause adjacent posts to loosen in their footing and to begin to wobble as well–causing further damage down the fenceline
Can you repair concrete posts?
Repairing a concrete post is inexpensive and easily done with a few supplies Damaged concrete posts can lead to serious structural problems that cost hundreds of dollars to repair Repairing a concrete post is inexpensive and easily done with a few supplies
Can you fix a loose fence post?
Fill the hole with approximately 6 inches of gravel Top the gravel with rapid-set cement mix powder to fill the hole to 3 inches below the surface of the soil Use the rubber mallet to pound the fence post into place and place the spirit level on top of the post to ensure that it’s level vertically
What is a concrete spur post?
Concrete spurs provide an economical alternative to replacing wooden fence posts that have rotted away at ground level Available in sizes from 1050mm to 1500mm, concrete spurs are suitable for use with most types of wooden post
What is a fence Spur?
Description Concrete Repair Spurs are used to repair broken or rotted fence posts or they can also be used for bolting posts or timber frame work above the ground
Are concrete Spurs reinforced?
Concrete Spurs 100 x 100 x 1200mm are used to repair broken timber posts and are an alternative to replacing the whole post Being concrete and reinforced with steel rods they give a permanent solution once concreted in and bolted to the remaining post
Can you put Postcrete in before water?
Postcrete is designed to be put in the whole dry Normally after you put the dry concrete and the post in the hole you just pour water in on top of the dry mix
How much water do you put in a bag of Postcrete?
Fill hole with water to a third of the depth 3 Pour in POSTCRETE evenly around post until no standing water is visible (powder completely covers water surface) Sprinkle water on top of powder
Can you add gravel to Postcrete?
Another “old rule of thumb” for mixing concrete is 1 cement : 2 sand : 3 gravel by volume Mix the dry ingredients and slowly add water until the concrete is workable This mixture may need to be modified depending on the aggregate used to provide a concrete of the right workability
Why deck posts should not be set in concrete?
A deck post should always be placed on top of footing, not inside concrete because it can break Concrete tends to absorb moisture and wood expands when it gets wet, so these two factors combined will result in the wood breaking the concrete
How do I anchor a post to the ground?
Step-By-Step Instructions: Dig the post hole, making it three times the width of the post and at a depth equal to 1/3 to 1⁄2 of the above-ground length of the post, plus 6″ (right) Pour 6″ of gravel or crushed stone into the bottom of the hole Set the post in the hole
How long will a 6×6 post last in concrete?
A PT post will last a long time in concrete, maybe 5 to 10 years in soil alone I suggest you embed the post in concrete, trowel a peak around the post so water runs off, and don’t let the PT post come in contact with the ground